Zenoah G310TS Specifications

OWNER/OPERATOR MANUALCHAINSAWS2875-93111(005)The engine exhaust from this productcontains chemicals known to the Stateof California to cause cancer,

6. Fuel and Chain oil CHAIN OIL Use motor oil SAE 10W-30 all year round, or SAE30-40 in summer and SAE 20 in winter. Do not use waste or regenerated

FUELING THE UNIT (OP1)1. Remove the fuel tank cap and pour fuel into thetank up to 80% of full capacity. 2. Fasten the fuel cap securely and wipe up

❲12❳OP87. Operation CHECKING OIL SUPPLY After starting the engine, run the chain at mediumspeed and see if chain oil is scattered off as shownin the

so that saw chain does not turn. If idling speed istoo slow, turn the screw clockwise. (OP8)4. Make a test cut adjust the H needle for bestcutting pow

• Before proceeding to your job, read “For SafeOperation” section. It is recommended to firstpractice sawing easy logs. This also helps youget accusto

should stop immediately with the engineat full speed. If the chain is slow to stop ordoes not stop then replace the brake bandand clutch drum before u

of bending direction to prevent the guide bar frombeing caught in the cutaway. ● Cutting an unpillowed log Saw down halfway, then roll the log over an

❲17❳9. MaintenanceMake sure to stop the engine before inspectingand/or servicing the unit. DAILY MAINTENANCE SAW CHAIN It is one of the essential fa

❲18❳9. MaintenanceGUIDE BAR 1. Remove sawdust in the bar groove and theoiling port. (MA5)2. Grease the nose sprocket from the feeding porton the tip o

anything wrong be found, make sure to have itrepaired before next usage. MONTHLY MAINTENANCE FUEL FILTER When the engine runs short of fuel supply,

❲20❳SPARK ARRESTER RedMax engines are equipped with a sparkarresting screen at the exhaust port. Periodicallycheck and keep it in good condition. In t

❲21❳11. Parts list NOTE : 1. Use KOMATSU ZENOAH genuine parts as specified in the parts list for repair and/orreplacement. 2. KOMATSU ZENOAH does not

❲22❳11. Parts listFig.1 POWER UNITG310TS (S/N 002191 and up)G310TS

❲23❳Fig.1 POWER UNIT (S/N 002191 and up)G310TS1 2870-12111 CYLINDER 12 2633-15100 MUFFLER ASS’Y 13 2633-15110 • BASE 14 2633-15120 • COVER 15 2630-15

❲24❳11. Parts list Fig.2 CARBBURETOR COMPONENTS & ACCESSORIES (S/N 002191 and up)G310TS

❲25❳Fig.2 CARBBURETOR COMPONENTS & ACCESSORIES (S/N 002191 and up)G310TSKey# PART NUMBER DESCRIPTIONQ'TY/UNITNOTE Key# PART NUMBER DESCRIPTIO

THE CALIFORNIA AIR RESOURCES BOARD AND KOMATSU ZENOAH Co. ARE PLEASED TOEXPLAIN THE EMISSION CONTROL SYSTEM WARRANTY ON YOUR 1995 AND LATER LAWN ANDGA

EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE MODEL G310TS UNIT, KOMATSU ZENOAH AMERICA INC. (THE COMPANY), THRO

© Printed in JapanPièces en rapport avec les émissions de gaz d'échappement : KOMATSU ZENOAH AMERICA INC., parl'intermédiaire de n'impo

SAFETY FIRSTInstructions contained in warnings within thismanual marked with a symbol concerncritical points which must be taken intoconsideration to

2. Specifications G310TSPower unit : Dis placement ····················································································· 1.9(30.1) c

3. Symbols on the machine❲5❳Made in JapanRedMax IMPORTANT ENGINE INFORMATION THIS ENGINE CONFORMS TO US EPA PH1 AND 1995-1998 CALIFORNIA EMISSI

❲6❳4. For safe operation1. Never operate a chain saw when you arefatigued, ill, or upset, or under theinfluence of medication that may makeyou drowsy,

❲7❳4. For safe operation16. Operate the chain saw only in wellventilated areas. Never start or run theengine inside a closed room or building.Exhaust

A standard saw unit package contains the items asshown. (SE1)Open the box and install the guide bar and the sawchain to the power unit as follows. The

6. Fuel and chain oil❲9❳ FUEL The RedMax engines are lubricated by oil speciallyformulated for air-cooled 2-cycle gasoline engineuse. If RedMax oil i